Showing 01 - 12 of 139 Results

shope

Acid Leaching Copper Ore Treatment Method

Metallurgical ContentAcid Leaching Process FlowsheetCHEMISTRY OF COPPER DISSOLUTIONPREPARATION OF THE COPPER ORESTORAGE AND FEEDING THE ORECOPPER LEACHINGCHARGING THE TANKSCOPPER PRECIPITATIONACID SUPPLYPRODUCTION OF SULPHURIC ACID The treatment of copper ores, both oxides and sulfides by means of flotation,

shope

A STUDY OF LEACHING OF COPPER OXIDE ORE BY SULPHURIC ACID

The Democratic Republic of Congo copper oxide ore containing mainly malachite was leached in sulphuric acid. The effects of leaching time, pH, stirring speed, and temperature on the dissolution

shope

Leaching of copper(I) sulphide by sulphuric acid solution

This paper aims to investigate the leaching process of copper(I) sulphide by sulphuric acid solution in the presence of sodium nitrate as it has not been studied sufficiently either from the theoretical or practical point of view. 2. Chemical reaction and thermodynamics

shope

Sulphuric acid leaching of zinc and copper from Nigerian

Sulphuric acid leaching of zinc and copper from Nigerian Complex sulphide ore also be catalyzed into hydroxyl radicals, which are extremely reactive. The dissolution of ores using sulphuric acid in conjunction with hydrogen peroxide has been studied and successful results were obtained.

shope

Copper Mining and Processing: Processing of Copper Ores

The leaching reagent (dilute sulfuric acid) is sprayed through sprinklers on top of the heap pile and allowed to trickle down through the heap, where it dissolves the copper from the ore. The resulting “pregnant” leach solution of sulfuric acid and copper sulfate is collected in a small pool.

shope

Leaching of copper oxide with different acid solutions

Oct 15, 2009· Leaching of copper oxide with different acid solutions. Author links open overlay panel N. Habbache N. Alane S sulfuric acid or nitric acid the reaction becomes: (2) CuO + 2HNO 3 The results indicate that the agitation has a more pronounced effect on the dissolution of copper with citric acid than that observed with inorganic acids.

shope

Heap leaching Wikipedia

This method is an acid heap leaching method like that of the copper method in that it utilises sulfuric acid instead of cyanide solution to dissolve the target minerals from crushed ore. The amount of sulfuric acid required is much higher than for copper ores, as high as 1,000 kg of acid per tonne of ore, but 500 kg is more common.

shope

Copper Mining and Extraction: Oxide Ores

This is scrubbed from the flue gases to make sulfuric acid for leaching copper from oxide ores. Scrubbing sulfur dioxide also protects the environment. A by-product of the smelting and converting furnaces is sulfuric acid. In what looks like a lucky coincidence, sulfuric acid is needed to treat oxide ores in processes called leaching and SX-EW

shope

LEACHING OF LOW-GRADE COPPER ORES: A CASE STUDY

leaching methods. Agents for leaching copper can be acid, base, or salt solutions. Of all of these agents, sulphuric acid has been given the broadest industrial application in hydrometallurgy of copper. The basic copper carbonate minerals, which are easily leached with the solution of sulphuric acid are: azurite, malachite and chrysocolla.

shope

Copper recovery using leach/solvent extraction

In 1968 there were only two widely practiced copper leaching processes using dilute sulphuric acid. The first process, vat leaching of high-grade copper oxide ore followed by EW of copper from the leach solution, produced low quality copper cathode at relatively high cost. In 1968 the tonnage of high-

shope

Sulfuric acid injection in copper heap leaching LEWA

Sulfuric acid injection in copper heap leaching The leaching reagent (dilute sulfuric acid) is sprayed through sprinklers on top of the heap pile and allowed to trickle down through the heap, where it dissolves the copper from the ore. The resulting solution of sulfuric acid and copper

shope

(PDF) Leaching of copper oxide with different acid solutions

Results of the first leaching experiment with 1 M sulphuric acid revealed that most of the copper that was extracted in total in this experiment (84 %) was dissolved during the first five minutes

shope

Sulfuric Acid Copper Leaching Osteria de L'Ortolano

Leaching Oxide Ores with Sulfuric Acid The flowchart above shows how the smelting process of sulfide ores produces sulphur dioxide, which is converted to sulfuric acid.

shope

sulfuric acid copper leaching YouTube

Sep 02, 2016· Copper(II) oxide, a black solid, and colourless Extraction of Tin and Copper by Acid Leaching of PCBs Sulfuric acid was found unable to leach the solder at low Leaching of copper and tin from

shope

Open Access The Leaching of Dolomitic-Copper Ore Using

Abstract: The leaching of dolomitic-copper ore using sulphuric acid under controlled conditions was studied with a view to evaluating the economic value and the effect of ore pulverisation, particle size, temperature and pH on the recovery of copper from chalcopyrite. The samples were ground and mixed with water and sulphuric acid to form an acid

shope

LEACHING OF A Cu-CoORE FROM CONGO USING

or vat operations, sulphuric acid is commonly used to leach copper from oxide minerals such as malachite (CuCO 3.Cu(OH) 2), azurite (2CuCO 3.Cu(OH) 2) and chrysocolla (CuO.SiO 2.2H 2 O). Sulphuric acid was also used to easily leach copper from a roasted Cu-Pb matte [4]. Such a leaching scheme however needs to

shope

Bioleaching: Introduction, Methods, Application, Copper

Bioleaching: Introduction, Methods, Application, Copper, Microorganisms, and Processes! Introduction to Bioleaching: Leaching process was first observed in pumps and pipelines installed in mine pits containing acid water. This process was later on employed for recovering metals from ores containing low quantity of the metal. Presently certain metals from sulfide ores and other ores are

shope

Does sulfuric acid react with copper? Quora

Copper does not react with dilute sulphuric acid as its reduction potential is higher than that of hydrogen. Copper does not displace hydrogen from non-oxidising acids like HCl or dilute H2SO4. But, concentrated sulphuric acid is an oxidising agen...

shope

Sulfuric acid: a dangerous mining aid NRS-Import DW

NRS-Import Sulfuric acid: a dangerous mining aid. Sulfuric acid is used to leach copper from the ground. But the method comes with considerable risks for the environment because of contamination

shope

sulfuric acid usage in copper leaching Gold Refining

Feb 04, 2016· All, In my previous post, i dropped 25litre of water plus 5 litre of 98% sulfuric acid for 90kg or copper ore. Is there any formula to know how much pure sufuric acid and water should be mixed for leaching reagent?

shope

Leaching Chalcopyrite Concentrate with Oxygen and Sulfuric

The mass balance showed that 98% of copper was extracted from the chalcopyrite concentrate in 3 h under the following experimental conditions: 130 g/L of initial sulfuric acid concentration, temperature of 100 °C, oxygen pressure of 1 kg/cm2, solid concentration of 100 g/L and particle size of −105 + 75 μm.

shope

Extraction of Tin and Copper by Acid Leaching of PCBs

Extraction of Tin and Copper by Acid Leaching of PCBs Amit Chaurasia*, Sulfuric acid was found unable to leach the solder at low concentrations, so further study was discarded. Perchloric acid was also found ineffective. nitric acid solution. Therefore, copper in the middle layer

shope

LEACHING OF A Cu-CoORE FROM CONGO USING

or vat operations, sulphuric acid is commonly used to leach copper from oxide minerals such as malachite (CuCO 3.Cu(OH) 2), azurite (2CuCO 3.Cu(OH) 2) and chrysocolla (CuO.SiO 2.2H 2 O). Sulphuric acid was also used to easily leach copper from a roasted Cu-Pb matte [4]. Such a leaching scheme however needs to

shope

Sulfuric acid: a dangerous mining aid NRS-Import DW

NRS-Import Sulfuric acid: a dangerous mining aid. Sulfuric acid is used to leach copper from the ground. But the method comes with considerable risks for the environment because of contamination

shope

Extraction of Tin and Copper by Acid Leaching of PCBs

Extraction of Tin and Copper by Acid Leaching of PCBs Amit Chaurasia*, Sulfuric acid was found unable to leach the solder at low concentrations, so further study was discarded. Perchloric acid was also found ineffective. nitric acid solution. Therefore, copper in the middle layer

shope

Sulfuric acid leaching of sulfide slag of Sarcheshmeh

leaching causes an increase in extraction of copper. In recent years, various solvents such as chlorate [13], ferric chloride [14], hydrochloric acid [15], hydrogen peroxide [16], and sulfuric acid [17] have been used for leaching of copper from slags. Sulfuric acid leaching is the most conventional method for extraction of copper because of its

shope

Leaching Chalcopyrite Concentrate with Oxygen and Sulfuric

The mass balance showed that 98% of copper was extracted from the chalcopyrite concentrate in 3 h under the following experimental conditions: 130 g/L of initial sulfuric acid concentration, temperature of 100 °C, oxygen pressure of 1 kg/cm2, solid concentration of 100 g/L and particle size of −105 + 75 μm.

shope

Leaching of metals from hydrometallurgical residue by

A direct leaching on the hydrometallurgical residue with sulfuric acid was developed in this work. The influence of leaching temperature, the leaching time, the particle size and the sulfuric acid concentration was examined. Results of leaching studies that the recovery extraction of Zn, Fe and Cu for hydrometallurgical residue increases with increasing acid concentration and temperature

shope

A statistical approach to the experimental design of the

Sulfuric acid leaching did not provide more than 76% copper extraction because the only slightly native copper that was leached (23%). For this reason, the sulfuric acid leach residue still had 0.30% native copper and 0.52% total copper.

shope

Extraction of Tin and Copper by Acid Leaching of PCBs

Rate of solder dissolution with time for different acid concentrations was studied. Sulfuric acid was found unable to leach the solder at low concentrations, so further study was discarded. Perchloric acid was also found ineffective. Nitric acid, a strong oxidizing agent has selective dissolution properties for copper, tin and lead.

shope

A comprehensive study of the leaching behavior and

the product layer, was found appropriate enough to describe the dissolution of copper in sulphuric acid solution. The activation energy was obtained to be 26.699 kJ/mol, and the equation representing the leaching kinetics of copper based on the di usion-controlled model was found to be 1 3(1 x)2=3+2(1 x) = 161:97 exp( 26:699 103=8:314 T) t.

shope

How to Make copper sulfate from copper and sulfuric acid

Watch this science video tutorial from Nurd Rage on how to make copper sulfate from copper and sulfuric acid in three ways. They show you how to make copper sulfate from copper and sulfuric acid using two chemical methods and one electrochemical method.

shope

Producing Copper Nature's Way: Bioleaching

Bioleaching involves the use of microorganisms to catalyze the oxidation of iron sulfides to create ferric sulfate and sulfuric acid. Ferric sulfate, which is a powerful oxidizing agent, then oxidizes the copper sulfide minerals and the copper contained is then leached by the sulfuric acid formed.

shope

LEACHING KINETICS OF COPPER FROM CHALCOPYRITE

Sulfuric acid processing with the addition of a small amount of nitrogen species has been employed for a long time in some industrial applications. The first patented commercial process by Sunshine Precious Metals (Idaho, USA) used a sulfuric and dilute nitric acid mixture to leach silver- and copper-bearing ores (Caldon, 1978).

shope

Oxidative pressure leaching of chalcocite in sulphuric

OXIDATIVE PRESSURE LEACHING OF CHALCOCITE IN SULPHURIC ACID by Ishwinder Singh Grewal B.A.Sc, The University of British Columbia, 1989 A THESIS SUBMITTED IN PARTIAL FULFILLMENT OF THE REQUIREMENTS FOR THE DEGREE OF MASTER OF APPLIED SCIENCE in THE FACULTY OF GRADUATE STUDIES Department of Metals and Materials Engineering We

shope

Sulfuric Acid Trammo

Sulfuric acid is a key element in the production of fertilizer (phosphates and ammonium sulfate) which is its primary use (approximately 65% of total consumption). Sulfuric acid is also used in the mining industry for leaching of copper, nickel, uranium and other elements from ores (approximately 15% of total consumption).

shope

Extraction of Tin and Copper by Acid Leaching of PCBs

Rate of solder dissolution with time for different acid concentrations was studied. Sulfuric acid was found unable to leach the solder at low concentrations, so further study was discarded. Perchloric acid was also found ineffective. Nitric acid, a strong oxidizing agent has selective dissolution properties for copper, tin and lead.

shope

Producing Copper Nature's Way: Bioleaching

Bioleaching involves the use of microorganisms to catalyze the oxidation of iron sulfides to create ferric sulfate and sulfuric acid. Ferric sulfate, which is a powerful oxidizing agent, then oxidizes the copper sulfide minerals and the copper contained is then leached by the sulfuric acid formed.

shope

Sulfuric Acid Trammo

Sulfuric acid is a key element in the production of fertilizer (phosphates and ammonium sulfate) which is its primary use (approximately 65% of total consumption). Sulfuric acid is also used in the mining industry for leaching of copper, nickel, uranium and other elements from ores (approximately 15% of total consumption).

shope

Valves for copper leaching, solvent extraction and

Heap leaching starts with the sprinkling of a low concentration sulfuric acid and water solution on a stockpile (leach pad) of low-grade ore. The liquid percolates through the stockpile and dissolves copper minerals, producing an approx. 60% copper concentration called pregnant leach solution (PLS).

shope

EP2650392A1 Method for leaching copper oxide, replacing

Process for the leaching of copper oxide without the utilization of sulphuric acid wherein it comprises impregnating said copper oxide using an organic non contaminant leaching agent which consists in a aqueous solution composed by tricarboxylic acid (C 6 H 8 0 7 ) in combination with water, in a mixture with an acidity varying between pH 1.0 to 5.0; obtain copper citrate; and optionally

shope

Valve solutions for copper leaching, solvent extraction

leaching, which is one of the most common leaching methods, starts with sprinkling a low concentration of sulfuric acid and water solution on a stockpile (leach pad) of low-grade ore. The liquid percolates through the stockpile and dissolves copper minerals, producing a copper-rich liquid called a pregnant leach

shope

LEACHING KINETICS OF COPPER FROM CHALCOPYRITE

Sulfuric acid processing with the addition of a small amount of nitrogen species has been employed for a long time in some industrial applications. The first patented commercial process by Sunshine Precious Metals (Idaho, USA) used a sulfuric and dilute nitric acid mixture to leach silver- and copper-bearing ores (Caldon, 1978).

shope

Oxidative pressure leaching of chalcocite in sulphuric

OXIDATIVE PRESSURE LEACHING OF CHALCOCITE IN SULPHURIC ACID by Ishwinder Singh Grewal B.A.Sc, The University of British Columbia, 1989 A THESIS SUBMITTED IN PARTIAL FULFILLMENT OF THE REQUIREMENTS FOR THE DEGREE OF MASTER OF APPLIED SCIENCE in THE FACULTY OF GRADUATE STUDIES Department of Metals and Materials Engineering We

shope

The leaching of sulfide iron (II) with sulfuric acid

Aug 25, 2015· The leaching of iron (II) sulfate concentrate from Chaabet El Hamra, Algeria bulk sulphide ore with sphalerite concentrate in presence of sulfuric acid and hydrogen peroxide at low stirring rates (100 rpm). The influence of leaching temperature, leaching time, particle size and sulfuric acid concentration were studied.

shope

The Role of Sulphuric Acid in Copper Plating

The more sulfuric acid you add, the better is your throwing power, for example a usual copper electrolyte contains about 60 g/l Sulfuric acid, a copper electrolyte for plating printed circuit, which have very small holes to plate in, contains about 220 g/l Sulphuric acid.

shope

Investigation on leaching of malachite by citric acid

Abstract. Leaching of an oxidized copper ore containing malachite, as a new approach, was investigated by an organic reagent, citric acid. Sulfuric acid is the most common reagent in the leaching of oxide copper ores, but it has several side effects

shope

Leaching Oxidized Copper Ores: Effect of Strength of Acid

especially in leaching ores of the Southwest, the first experiments were limited to oxidized ores and to sulphuric acid as the leaching solvent. Continuation of this work was inter-rupted owing tb exigencies and lack of personnel. The data collected were thought suffi-cient, however, to justify this publication. ACKNOWLEDGMENTS

shope

Copper Carbonate and Sulfuric Acid YouTube

Oct 08, 2010· The reaction between copper carbonate and sulfuric acid is investigated to determine the word equation. testing the gas using limewater. (Music from free-loops Creative commons)

shope

How Hydrometallurgy and the SX/EW Process Made Copper the

Because of its dependence on sulfuric acid, the SX/EW Process is at present not a substitute for, but rather an adjunct to conventional smelting. However, it is also applicable in locations where smelter acid is not available by the purchase of sulfuric acid or the manufacture of sulfuric acid from sulfur or pyrite.